Volkswagen Polo Service & Repair Manual: Wax Spray -D 322 100 M2
| Wax Spray -D 322 100 M2- is a long-term anti-corrosion
agent. After drying, the product forms a light brown, wax-like
film. Because of its hardness, the Wax Spray provides good
protection against mechanical stress. |
| Wax Spray -D 322 100 M2- technical application information |
| The material is primarily used in the vehicle area, but it
is also used as temporary corrosion protection for tools and
machines. |
| The Wax Spray does not corrode vehicle paint and adheres to
almost all base surfaces. |
 Note
| Before starting to apply, it is necessary to read the safety
measures and advice in the safety data sheet. |
| Even for products which are not required to be labeled by
law, the usual safety measures must be observed for chemical
emissions. |
| Bring the Wax Spray to room temperature (16° to 20 °C (60.8°
to 68 °F). |
| Briefly shake the spray can before using. |
| The surfaces that are to be treated (underbodies, wheel
housings, insides of door) must dry and be free of grease and
dust. |
| The Wax Spray is sprayed on evenly in cross coats at a
distance of 20 to 30 cm. |
Caution
| Do not spray onto the steering, engine, driveshaft,
exhaust, catalytic converter and brake systems. |
|
|
|
|
| Base |
Wax mixture |
| Color |
Light brown/transparent |
| Film type |
Hard and wax-like |
| Density |
0.735 g/cm³ |
| Solids content |
35.4 % |
| Flashpoint/Active agent |
29 °C (84.2°F) |
| Flashpoint/Spray |
< -20 |
| Recommended layer
thickness |
50 µm/wet |
| Drying time |
approximately 30 minutes |
| Heat stability |
105 °C (221 °F) |
| Removability |
Mineral spirits |
| Processing temperature |
16 to 20 °C (60.8 to 68
°F) |
| Propellant gas (Aerosol) |
Propane / Butane |
| Aerosol storage |
Cool and dry, < 50 °C
(122 °F) |
| Hazard warning |
Highly flammable |
| Container |
500 ml |
Definition:
Wax Underbody Protection -D 316 000 A1-
Edition 01/2008
Product Description
...
Other materials:
Refrigerant in A/C Service station Container, Filling
Caution
If it is suspected that chemicals were added to the
refrigerant circuit to seal leaks, do not connect the
A/C service station and do not extract the refrigerant.
...
Introduction
This chapter contains information on the following subjects:
→ Fuses in the vehicle
→ Changing a blown fuse
At the time of print we are unable to provide an up-to-date overview of the
locations of the fuses for the electrical consumers. This is because the vehicle
is under co ...
Handling Pressure Vessels
Secure vessels to prevent them falling over!
Secure upright cylinders to stop them falling over and
cylinders lying flat to stop them rolling away.
Do not throw vessels!
If dropped, the vessels cou ...
© 2016-2026 Copyright www.vwpolo.net
Wax Underbody Protection -D 316 000 A1