Volkswagen Polo Service & Repair Manual: Visual Inspection
WARNING
Risk of injury. Follow all Warnings and Safety
Precautions. Refer to
→ Chapter „Warnings and Safety Precautions“. |
|
Prior to performing any measurements or tests, perform a
visual check of the battery condition, battery terminals and
secure mounting of battery. |
Note
For each vehicle. Refer to for information regarding the
battery. |
Caution
An improperly secured battery can lead to damage. |
Excessive vibration due to an improperly secured
battery will reduce the battery service life, and the
battery hold-down bracket could damage the battery
housing and lead to electrolyte leakage. |
Check the battery for secure fitting, if necessary
tighten the mounting bolt to the tightening
specification. |
|
By Performing Visual Inspection, it can be Determined: |
If the battery case is damaged. Acid can leak out if the
case is damaged. Battery acid that has leaked out can cause
severe damage to the vehicle. Acid that has leaked onto any part
of the vehicle should be immediately treated with acid
neutralizer or soap solution. |
If the battery terminals (battery wiring connections) are
damaged. If the battery terminals are damaged, contact with
battery terminals clamps cannot be guaranteed. When connecting
the battery pole shoes, keep in mind that the tightening
specification from the “Electrical Equipment” repair manual for
the corresponding vehicle is used. If the battery post clamps
are not correctly installed and secured, the wiring may burn.
Substantial malfunctions to the electrical system are a
consequence. Safe operation of the vehicle can no longer be
guaranteed. |
|
|
|
Perform Battery Checks in the Following Sequence:
1.
Visual inspection. Refer to
→ Chapter „Visual Inspection“.
...
Other materials:
Stowage compartment in the front centre armrest
Fig. 96 Stowage compartment in the front
centre armrest
First read and observe the introductory information
and safety warnings
To open, press the release button in the centre armrest (arrow) and lift
the cover all the way up.
To close, guide the cover down.
WARNING
The centre armrest ...
Wire Break with Single Repair Point
Repair point with single crimp connection
–
Free up wire intended for repair (approximately 20 cm to
both sides of repair point).
–
If required, remove wiring harness wrapping using a folding
...
General Information
The following descriptions also apply to Left Rear Cigarette
Lighter -U3-, Right Rear Cigarette Lighter -U7-, Rear Cigarette
Lighter -U9-, 12 V Socket 2 -U18-, 12 V Socket 3 -U19-, 12 V
Socket 4 -U20-, Cigarette Lighter 2 -U25- and 12 V Socket 5
-U26- if ...
© 2016-2024 Copyright www.vwpolo.net