Volkswagen Polo Service & Repair Manual: Safety Precautions
Safety Precautions when Painting Vehicles with Electric Drive
Caution
| Risk of damaging the battery cells at too high of
drying temperatures! |
| Observe the maximum drying time of 30 minutes at a
drying temperature of +80 °C (176 °F). |
| Observe the maximum drying time of 45 minutes at a
drying temperature of +60 °C (140 °F). |
| Protect all high-voltage components from direct
infrared radiation when IR drying. |
|
| Observe the Safety Precautions when Working on the Electric
Drive: |
| The above named drying information applies only to the Golf
MY 2009 blue-e-motion. For this vehicle the high-voltage battery
must be removed before heated drying. |
|
|
|
Other materials:
Evacuating and Charging Valve, High Pressure Side
Special tools and workshop equipment
required
Torque Wrench 1783 - 2-10Nm -VAG1783- with Torque Wrench
1783 - 1/4" Drive Ratchet -VAS6234-
WARNING
There is a dan ...
Introduction
This chapter contains information on the following subjects:
→ Preparing the vehicle for working in the engine compartment
→ Opening and closing the bonnet
Always park the vehicle on a level and stable surface before carrying out any
work in the engine compartment.
The engine ...
Beru Wheel Electronics Tire Pressure Monitoring Sensor, Removing and
Installing
Overview, Beru System
WARNING
If tire sealant was used, then the wheel electronics
on that particular wheel must be replaced.
WA ...
© 2016-2026 Copyright www.vwpolo.net
