Volkswagen Polo Service & Repair Manual: Components, Replacing
- General Information
- Leaking or Damaged Components except A/C Compressor, Reservoir or Receiver/Dryer
- A/C Compressor, Replacing
- Receiver/Dryer or Reservoir and Restrictor, Replacing
Checking with Expansion Valve, Receiver/Dryer and A/C Compressor Regulator
Valve -N280-, Externally Regulated A/C Compressor
Specified Values
Note
Connecting service station. Refer to
→ Chapter „Connecting Service Station ...
General Information
All components of the refrigerant circuit submitted for
quality observation are always to be sealed (use original
sealing caps of original part).
...
Other materials:
Single Wire Seals, Installing
Note
Single wire seals prevent the penetration of water and dirt
into the contact housing. They are installed, for example, in
the engine compartment and must be reinstalled after a repair.
Single wire seal is crimpe ...
Valve, Removing and Installing, Rubber Valve
Make sure wheel rim is clean.
–
Using the Valve Fitting Tool Valve Fitting Tool -VAS6459--1-,
insert a new tire valve.
–
Remove the valve insert.
...
Pressures, Checking
Note
Check cooling performance. The A/C system is functioning
correctly when the air flowing from the instrument panel vents
has a temperature of 70C or lower.
Setting on Climatronic “LO”.
...
