Volkswagen Polo Service & Repair Manual: Additional Information Sources
| Technical Service Handbook outlining action to be taken to
rectify current problems. |
| For the repair manual for model-specific repair work. Refer
to
→ Heating, Ventilation and Air Conditioning; Rep. Gr.87. |
| → Wiring diagrams, Troubleshooting & Component locations |
| Sections of Self Study Program number 208 are no longer
up-to-date. An example of this is the statement “The
receiver/dryer is replaced each time the refrigerant circuit is
opened”. The following prerequisites apply. Refer to
→ Anchor |
| Video programs for in-dealership training. |
| Special Tools and Workshop Equipment Catalog. |
| Service Organization Volume 1 Additional Equipment. |
| Repair manual Air Conditioning with Refrigerant R12. Only
hardcopies of this manual are available for vehicles through MY
1993. |
|
|
|
The purpose of this Repair Manual is to provide foremen and
mechanics with the basic knowledge needed to ensure expert
working.
Note
...
Other materials:
Special Connector Systems
Note
If necessary, housing securing mechanisms (secondary locks)
must be released or removed using specified tool before
releasing the contacts. Refer to
→ Chapter „Secondary Lock“.
...
Tires, Dismounting, Run-Flat Tires and Ultra High Performance Tires
Only trained personnel can perform the assembly work on
run-flat tires and ultra high performance tires.
If equipped check the tire pressure monitoring sensor with
the vehicle diagnostic tester and if necessary replace.
...
Single Wire Seals, Installing
Note
Single wire seals prevent the penetration of water and dirt
into the contact housing. They are installed, for example, in
the engine compartment and must be reinstalled after a repair.
Single wire seal is crimpe ...
© 2016-2026 Copyright www.vwpolo.net
Introduction